Hotline
+86 512-81666096121,20000m ³ Calculation of maximum make-up gas volume of LNG full capacity tank - Doer equipment
Classification:Forum PublishTime:2019-11-19 14:41:09
20000m ³ Calculation of maximum make-up gas volume of LNG full capacity tank
twenty thousand ³ Determination of gas make-up volume of LNG full capacity tank
The amount of gas generated under the following conditions shall be considered for supplement;
(1) LNG pump outgoing
(2) Bog fan suction
(3) Atmospheric pressure rise
In normal operation of LNG low-temperature and atmospheric pressure storage tank, these three situations causing negative pressure of storage tank may occur. Under the three working conditions, the sum of air replenishment is the maximum air replenishment of storage tank.
1、 Air replenishment caused by LNG submerged pump
The flow of submersible pump is 450m ³/ h. The storage tank is equipped with two submerged pumps. Doer to the start of the submerged pump, the required air make-up volume of the side storage tank is:
F1=2 × four hundred and fifty × 1.05=945m ³/ h
Where:
450 - flow of submersible pump, M ³/ h
1.05 - coefficient
2 - two submersible pumps
2、 Air replenishment caused by bog compressor
The gas volume of bog compressor is assumed to be 2500nm at full load ³/ h. Then the storage tank needs air replenishment Doer to the start of bog compressor
The quantity is:
F2=2500 × 1.05=2625m ³/ h
Where:
1600 - flow of bog compressor, M ³/ h
1.05 - coefficient
3、 Air replenishment caused by atmospheric pressure rise
The air replenishment capacity with local atmospheric pressure of 97kpa is:
F3=13633/97 × 1.5=210.8m ³/ h
Where:
13633 - maximum volume of gas phase space, M ³
1.5 - ratio
97 - atmospheric pressure kPa
Maximum air make-up volume of storage tank:
F=F1+F2+F3=945+2625+210.8=3780.8m ³/ h
Conclusion: the air replenishment capacity of the storage tank is 3780.8m ³/ h. This value is used as the basis for the selection of suction valve and air replenishment device of storage tank
Prev: 120,20000m ³ Bog calculation under leakage condition of LNG full capacity tank - Doer equipment
Next: 162,What are the storage methods of LNG cryogenic storage tanks( 1) -Doer equipment
News
- 216、Advantages of Double Metal Full Capacity Tank … [2023-05-09]
- 215、Design principles for low-temperature storage … [2023-05-09]
- 214、Low temperature storage tank safety education … [2023-05-09]
- 213、Objectives of project construction management-… [2023-05-09]
- 212、Quality service advantages of Doer large low-t… [2023-05-09]
- 211、Advantages of Doer Large Low Temperature Stora… [2023-05-09]
- 216、Design scope of atmospheric and low-temperatur… [2023-05-08]
- 215、Process flow of low-temperature LNG storage ta… [2023-05-08]
- 214、Testing methods for low-temperature argon stor… [2023-05-08]
- 213、Performance Description of Low Temperature Eth… [2023-05-08]